TNG GS 150 By curt (Read 395 times)

[curt]

Does anyone have a service manual for a TNG 150 GS  year 2008
Or at least spec sheet.  Currently I have replaced the cdi and coil
It appears the problem of run and die is with the pick up coil
One of the spark.  After spending to many hours on the internet
have not  found anyone with this problem.  Spec sheet would be nice
just find out the gap for valves,  Currently have 2200 miles on scoot
I bought it new and has been stored in side and seen little or no rain
Thanks Curt   319  331 1306

[alleyoop]

If it runs and after you ride it and the motor gets hot and when coming to stops it dies the problem is most likely the Valves need to be adjusted if so Adjust them both to .004 inch.

If it was stored for more a long time and it had gas in it the problem could be that the carb needs some cleaning. Leaving gas in the carbs the tiny holes varnish up and block the fuel from flowing.
If it starts ok and then within 3-4 minutes it dies then that is most likely the problem that the carbs Pilot Jet and Passage need to be cleaned.

But please explain exactly what is happening, the run and die when does it happen need detail to diagnose your problem.
So explain what you do and when does it die after certain minutes after starting it cold or after you ride it etc..
A Video if you can will also help if you cannot explain it clearly.
Alleyoop

[JR]

May 15, 2014 9:09:20 GMT -6 curt said:

Does anyone have a service manual for a TNG 150 GS  year 2008
Or at least spec sheet.  Currently I have replaced the cdi and coil
It appears the problem of run and die is with the pick up coil
One of the spark.  After spending to many hours on the internet
have not  found anyone with this problem.  Spec sheet would be nice
just find out the gap for valves,  Currently have 2200 miles on scoot
I bought it new and has been stored in side and seen little or no rain
Thanks Curt   319  331 1306

.thescooterprofessor.proboards.com/thread/331/tng-manuals" rel="nofollow" target="_blank">.thescooterprofessor.proboards.com/thread/331/tng-manuals